Suzuki Quadracer HQ

LT250R Quadracer => LT250R - Engine => Topic started by: LT250RWV on January 11, 2014, 01:38:54 pm

Title: Re: idle raising when I pull the choke
Post by: BadMoonRacing500 on January 12, 2014, 02:59:31 pm: Quote from: MotorGeek on January 12, 2014, 02:07:27 pm
Quote from: LT250RWV on January 11, 2014, 11:54:51 pm
Well I done the leak down test. It was good. Just weird it started doing this all a suden.

Did you check the choke jet that I mentioned in the above post
I was wondering the same thing Jerry?
Title: Re: idle raising when I pull the choke
Post by: MotorGeek - Jerry Hall on January 12, 2014, 02:07:27 pm: Quote from: LT250RWV on January 11, 2014, 11:54:51 pm
Well I done the leak down test. It was good. Just weird it started doing this all a suden.

Did you check the choke jet that I mentioned in the above post
Title: Re: idle raising when I pull the choke
Post by: LT250RWV on January 11, 2014, 11:54:51 pm: Well I done the leak down test. It was good. Just weird it started doing this all a suden.
Title: Re: idle raising when I pull the choke
Post by: MotorGeek - Jerry Hall on January 11, 2014, 09:26:45 pm: Quote from: LT250RWV on January 11, 2014, 01:38:54 pm
Here lately everytime I choke the bike when its cold the idle been going really high let off the choke and idles just fine. Switch carbs to a new and still is doing it. Never down this before. Any suggestion to this

The jet that regulates "choke mixture" is located in the float bowl at the bottom of the hole that small brass tube hangs down into.... The small brass tube is the fuel pick up for the choke circuit. Make sure the jet (it is not removable, it is pressed into the bottom of the hole) is not partially restricted. A layer of varnish on the inside of the jet can make the jet behave like it is a much smaller jet.

You could enlarge the jet by increasing the diameter by .001" at a time until you get the choke mixture "right" for the winter temperature but might be too rich in the summer.
Title: Re: idle raising when I pull the choke
Post by: LT250RWV on January 11, 2014, 09:12:20 pm: My quad has never done this before. Even after it warmed up by 30 degrees. I mean it sound like it wants to run off. Before it would raise a little . But its insane by how much its raised. Getting ready to do a leak down test in a few minutes.
Title: Re: idle raising when I pull the choke
Post by: Chuckie25 on January 11, 2014, 08:42:19 pm: Yup mine does this as well when it's cold out. I only need to use the choke to start it if it's below 30°. Then it sounds like it's on a lean death note but once I drop the choke it's fine
Title: Re: idle raising when I pull the choke
Post by: Rider414 on January 11, 2014, 08:08:58 pm: Sound pretty normal when it's cold out.
Title: idle raising when I pull the choke
Post by: LT250RWV on January 11, 2014, 01:38:54 pm: Here lately everytime I choke the bike when its cold the idle been going really high let off the choke and idles just fine. Switch carbs to a new and still is doing it. Never down this before. Any suggestion to this