Suzuki Quadracer HQ

Suzuki Quadracer HQ Discussion => Suzuki Quadracer HQ - General Discussion => Topic started by: PHIL on February 22, 2013, 02:22:48 pm

Title: Re: Carb Symptom , Leaking gas out of bowl I think. Need Help
Post by: Sublunacy on February 25, 2013, 07:49:17 pm

the O-rings need to be replaced. Either find a generic o-ring kit. Or get the right ones.

Under the nut that holds the choke lever on, that o ring is the one that needs attention and the hidden one around the main jet in the center that looks like a large brass plug(needle goes into it).

cost is 1.00 total maybe or a carb kit

Title: Re: Carb Symptom , Leaking gas out of bowl I think. Need Help
Post by: GrkGuy on February 23, 2013, 07:28:47 am

clean carb, take valve seat off and use a q tip to clean passage,
clean o ring and put a tiny drop of 2 stroke mix on it when you put it back in.

Title: Re: Carb Symptom , Leaking gas out of bowl I think. Need Help
Post by: PHIL on February 23, 2013, 06:53:32 am

Its not a a lot but enough to drip on the garage flow for a bit.

Title: Re: Carb Symptom , Leaking gas out of bowl I think. Need Help
Post by: Rainman56 on February 22, 2013, 03:47:07 pm

How much gas is it leaking?Is it worse with the engine off?I,d suspect the float height is off or some dirt or faulty needle and seat.Generally a needle and seat will run excessively rich but I have seen a few where it seaps a little periodically.

Title: Carb Symptom , Leaking gas out of bowl I think. Need Help
Post by: PHIL on February 22, 2013, 02:22:48 pm

Hey guys just needed to confirm something, I have a 92 LT250R and it runs great but the it seems to be leaking gas out of the little tube that comes off the carb and hangs down toward the ground , I assume this is the overflow thing off the bowl of the carb. My question is does this mean I need to rebuild the whole thing or can I take it apart and clean it up and possibly fix the issue? I think this means the float in the carb is stuck right?